The Most Common Toyota Tundra Problems

The Toyota Tundra is a well-loved truck among drivers and Toyota fans alike. With a long legacy like the Tundra has, there are bound to be issues at some point. What are some of the issues Toyota Tundra owners have experienced? The 2021 and 2020 models will likely have fewer problems overall because the vehicles are new. But don’t count out the used Toyota Tundra vehicles just yet.

Some noted 2017+ Toyota Tundra issues

The Most Common Toyota Tundra Problems
The Most Common Toyota Tundra Problems | Toyota

To get a better picture of some of the owner-reported issues, going back to the 2019 Toyota Tundra gives us a better look. Some of the owner-reported issues include braking and emergency handling. Additionally, Consumer Reports noted issues with body integrity as well. This includes things like “Squeaks, rattles, wind noises, loose or cracked seals and/or weather-stripping, air and water leaks.”

Owners reported that there was an air leak in the firewall and that there were issues with the rear windows sealing. As far as other issues, the National Highway Traffic Safety Administration (NHTSA) has issued seven recalls for the 2019 Toyota Tundra.

One of the recalls related to a failing fuel pump that can cause the engine to stall, increasing the risk of a crash. One refers to a small label about to the towing capacity being incorrect and exterior lights not flashing brightly enough. A final recall mentions that the airbags might not deploy as intended. The 2018 Tundra has similar recall notices listed.

Even with some of these issues, Consumer Reports still recommends all of the Tundra models from 2020 through 2009.

Pre-2016 Toyota Tundra models

The Toyota Parts Center has a list of common problems owners experience. Another commonly reported issue in older Tundras is related to the secondary air injection system. After a few years, this system can start to rust. Since Toyota vehicles tend to last a long time, this problem can present itself a few years into ownership. Since this was such a widespread issue, Toyota extended the warranty for Tundras for six years or sixty thousand miles.

Another common issue was the factory integrated brake controller (IBC). This does not provide enough stopping power when vehicles are towing. Many owners fixed this by installing an aftermarket brake controller. However, Toyota issued recalls for the label on many later-year Tundra models.

For 2007 through 2010 Tundra models, an ineffective floor mat design could cause the accelerator pedal to get stuck. This required a new set of floor mats, a pedal replacement, or a different-shaped floor mat altogether. Toyota recalled the trucks for these issues to fix it.

Some of the issues were minor

Recalls and problems are common for all vehicles on the road. Oftentimes, these recalls are made before injuries occur to prevent injury altogether. Used Toyota Tundra vehicles still have plenty to offer drivers. There is a Toyota Tundra out there for everyone with so many years, trim levels, and body types.

All cars, trucks, and SUVs have issues, but Toyota works hard to correct the widespread ones. If you are looking for a solid used pickup truck, don’t shy away from the Tundra. Researching the vehicle ahead of time will give you a heads-up on potential issues. And as always, get an inspection on any used car before driving it home. It could save you headaches down the line.

RELATED: Consumer Reports: Best Fourth of July Deals on Toyota Cars